Acid leaching is used to extract alumina from fly ash with generally concentrated sulfuric acid as solvent and fluoride as co-solvent. This method has some problems such as low leaching rate, fluoride environmental pollution, etc. The factors influencing the leaching rate with orthogonal test method are studied in this paper. By optimizing the experimental conditions, not only is the leaching rate of aluminum improved but also the environmental pollution is reduced. The results show that when the temperature reaches the boiling temperature of the dissolution, the concentration of sulfuric acid is 12 mol/L, the solid-to-liquid ratio is 1:3, the elution time is 120 min, and m(KF):m(fly ash)=0.04, the leaching rate of aluminum can be up to 91.2%, and the toxic fluoride dosage is reduced by half in the same leaching rate.
ZHAO Su, LIU Dawei, ZHAO Yue, LÜ Jian, TIAN Zhongxin
. Research on Optimized Experimental Conditions of Acid Leaching to Extract Alumina from Fly Ash[J]. Science & Technology Review, 2014
, 32(23)
: 39
-44
.
DOI: 10.3981/j.issn.1000-7857.2014.23.005
[1] 薛忠秀, 李韶辉. 碱法从粉煤灰中提取铝硅的新探索[J]. 山东冶金, 2011, 33(3): 35-37. Xue Zhongxiu, Li Shaohui. Technology explore of extracting alumina and silicon from coal ash with alkali method[J]. Shandong Metallurgy, 2011, 33(3): 35-37.
[2] 翟玉春, 吴艳. 从粉煤灰中提取氧化铝和二氧化硅的研究[D]. 沈阳: 东北大学, 2008. Zhai Yuchun, Wu Yan. Study on extraction of A12O3 and SiO2 from fly ash[D]. Shenyang: Northeastern University, 2008.
[3] Park H C, Park Y J, Stevens R. Synthesis of alumina from high purity alum derived from coal fly ash[J]. Materials Science and Engineering: A, 2004, 367(1): 166-170.
[4] Matjie R H, Bunt J R, Van Heerden J H P. Extraction of alumina from coal fly ash generated from a selected low rank bituminous South African coal[J]. Minerals Engineering, 2005, 18(3): 299-310.
[5] 岑可法, 周昊, 蒋啸. 不同细度煤粉燃烧特性及粉煤灰酸浸处理中硫 酸铝铃循环利用试验研究[D]. 杭州: 浙江大学, 2008. Cen Kefa, Zhou Hao, Jiang Xiao. Experimental research on combustion characteristics of coal powder with different fineness and cycling utilization of aluminum ammonium sulfate from fly ash by acid treatment[D]. Hangzhou: Zhejiang University, 2008.
[6] Fernandez A M, Ibanez J L, Llavona M A, et al. Leaching of aluminum in Spanish clays, coal mining wastes and coal fly ashes by sulphuric acid[J]. Light Metals: Proceeding of Sessions, 1998, 1: 121-130.
[7] 李环亭, 董艳艳, 刘晓毅, 等. 氟硅酸钾沉淀-酸碱滴定法测定硅质耐火材料中二氧化硅[J]. 冶金分析, 2011, 31(2): 67-70. Li Huanting, Dong Yanyan, Liu Xiaoyi, et al. Determination of silicon dioxide in siliceous refractory materials by potassium fluosilicate precipitation-acid base titration method[J]. Metallurgical Analysis, 2011, 31(2) : 67-70.
[8] 左平, 胡郑毛. 用EDTA容量法快速测定铁矿石中的铝含量[J]. 金属 矿山, 2008(4): 77-80. Zuo Ping, Hu Zhengmao. Rapid determination of the aluminum content in iron ore by EDTA volumetric method[J]. Metal Mine, 2008(4): 77-80.
[9] 贺晓唯, 毕诗文, 周金海. 铝酸钠溶液中苛性碱碳酸碱和氧化铝含量 的连续测定[J]. 吉林大学学报: 理学版, 2006, 44(5): 821-823. He Xiaowei, Bi Shiwen, Zhou Jinhai. Determination of caustichydroxide, sodium carbonate and alumna in sodium aluminate solutions[J]. Journal of Jilin University: Science Edition, 2006, 44(5): 821-823.
[10] Blanco F, Garcia M P, Ayala J. Variation in fly ash properties with milling and acid leaching[J]. Fuel, 2005, 84(1): 89-96.
[11] 唐明, 陈宁. 工程试验-优化设计[M]. 北京: 中国计量出版社, 2009. Tang Ming, Chen Ning. Engineering test-optimization design[M]. Beijing: China Metrology Press, 2009.
[12] 王文静, 韩作振, 程建光, 等. 酸法提取粉煤灰中氧化铝的条件选择[J]. 能源环境保护, 2003, 17(4): 17-19. Wang Wenjing, Han Zuozhen, Cheng Jianguang, et al. The with drawing of oxidize the aluminum form the fly ash[J]. Energy Environment Protection, 2003, 17(4): 17-19.
[13] 谢炜平, 李红霞. 酸溶-微波热解法从粉煤灰中制取聚合氧化铝的研 究[J]. 环境工程, 1999, 17(2): 50-52. Xie Weiping, Li Hongxia. Acid soluble-microwave pyrolysis of preparing polymeric aluminum oxide from fly ash in research[J]. Environmental Engineering, 1999, 17(2): 50-52.
[14] 李来时, 翟玉春, 吴艳, 等. 硫酸浸取法提取粉煤灰中氧化铝[J]. 轻金 属, 2006(12): 9-12. Li Laishi, Zhai Yuchun, Wu Yan, et al. Sulfuric acid leaching method extracting alumina in fly ash[J]. Light Metals, 2006(12): 9-12.
[15] 李来时, 刘瑛瑛. 硫酸浸出法提取氧化铝的热力学讨论[J]. 轻金属, 2009(5): 19-22. Li Laishi, Liu Yingying. Thermodynamics of alumina leached by sulfuric acid process[J]. Light Metals, 2009(5): 19-22.
[16] 丁宏娅. 采用改进酸碱联合法从高铝粉煤灰中提取氧化铝的研究[D]. 北京: 中国地质大学, 2007. Ding Hongya. With the improved acid-base joint research of extracting alumina from alumina powder coal ash[D]. Beijing: China University of Geosciences, 2007.
[17] Lin J, Liu R, Chen D. The progress in the technology of extracting the alumina oxide from the fly ash[J]. Chinese Journal of Process Engineerning, 2004(4): 271-274.
[18] 赵剑宇, 田凯. 氟氨助溶法从粉煤灰提取氧化铝新工艺的研究[J]. 无 机盐工业, 2003, 35(4): 40-41. Zhao Jianyu, Tian Kai. Study on extraction of aluminium oxide from fine coal ash by solubi lization of ammonium fluoride[J]. Inorganic Chemicals Industry, 2003, 35(4): 40-41.
